what are the common problems with a 2009 cayenne turbo s?

Question

Accepted Answer

The 2009 Porsche Cayenne Turbo S (part of the 957 generation) is a powerful machine, but like any performance SUV, it has some well-documented weak points to be aware of:

## 🔧 **Most Critical Issues**

### 1. **Plastic Coolant Pipe Failure** (V8 Models)
These were originally made of plastic and can crack under heat cycles, causing coolant loss, overheating, and potential engine damage. The pipes sit below the intake manifold where it gets hot. The fix is an **aluminum coolant pipe retrofit** — considered a must-do preventive repair.

### 2. **Transfer Case Shudder & Failure**
Symptoms include shudder under acceleration, clunking when shifting into Drive/Reverse, binding during tight turns, or AWD fault messages. The internal chain in the transfer case stretches over time, causing uneven torque distribution. They're prone to premature wear and can be costly to replace or rebuild.

### 3. **Centre Propshaft Bearing (Cardan Bearing)**
A thumping noise under acceleration or vibration through the floor are tell-tale signs. The rubber center support bearing degrades from torque loads and age. This is one of the questions mentioned on your listing — worth verifying if it's been addressed.

## ⚡ **Engine & Drivetrain Issues**

### 4. **Ignition Coils & Spark Plugs**
Misfires, rough running, and check engine lights (codes P0300–P0308) are common. The twin-turbo 4.8L V8 works hard and ignition components can fail prematurely — especially if the vehicle has been modified.

### 5. **Faulty Fuel Pumps**
The Turbo S has two low-pressure fuel pumps in the tank. These can overheat and fail, causing sputtering, stalling, or poor acceleration. Replacing both at once is recommended if one fails.

### 6. **Thermostat & Water Pump Failure**
The thermostat can stick closed or fail, leading to overheating. Often addressed alongside the water pump since they're in the same area and tend to fail around the same mileage.

### 7. **Oil Leaks (Valve Covers & Timing Covers)**
With age, gaskets harden and you'll notice burning oil smells or residue on the engine. Not catastrophic, but should be addressed to prevent belt contamination.

## 🚗 **Other Common Problems**

### 8. **Air Suspension Failure**
If equipped, the air struts can leak, the compressor can fail, or valve blocks get stuck. Symptoms include sagging overnight, constant compressor noise, or ride height warnings.

### 9. **ABS/PSM Warning Lights**
Usually caused by faulty wheel speed sensors — a relatively inexpensive fix, but requires proper Porsche diagnostics to pinpoint.

### 10. **Cardan Shaft Clunk**
Metallic clunk when shifting from Park to Drive/Reverse — often related to driveshaft couplings or transfer case output flange wear.

## 💡 **Bottom Line**

The 957 Turbos are mechanically robust when maintained, but the **plastic coolant pipes and transfer case** are the two big-ticket items to verify before purchasing. Many owners have already addressed the coolant pipe issue with aluminum retrofits, so ask about service history there. Regular synthetic oil changes and addressing issues early will keep that twin-turbo V8 running strong!

Would you like me to find comps with documented service history on the coolant pipes or transfer case replacement?

Lot 3076: 2009 Porsche Cayenne Turbo S

Classic cars

Cars for sale

Resources

Lot 3076: 2009 Porsche Cayenne Turbo S

Become a CLASSIC Insider